QA

Quick Answer: Why Does My Golf Cart Backfire

In almost all cases, whether it is a 2 cycle or 4 cycle engine, golf cart backfiring is caused by the accelerator cable being out of adjustment at the throttle plate of the carburetor. With the ignition key in the OFF position and the seat completely removed, press the accelerator pedal down.

How do I stop my golf cart from backfiring?

Start by carefully removing the drive belt with the engine off and then tweaking the adjustment screw as the engine is running. Adjust the screw until the engine is running as smoothly as possible. Now, you can fully tighten the screw, turn off the engine, and replace the drive belt to start your cart up again.

How do you adjust the carburetor on a Club Car golf cart?

Find the pilot adjustment screw on the edge of your carburetor. Pay attention to this screw – it should be a sharp point and not flat. Carefully remove this screw and then carefully screw it back. Turn this screw out one and one-half turns to adjust it properly.

How do you adjust the carburetor on a Easy Go golf cart?

2 Cycle engine: The adjustment screw is on the side of the carburetor and is parallel to the ground. You can identify it by the lock nut at the base of the screw. Loosen this and turn the screw all the way into a soft seat, then back it out one and a half (1-1/2) turns.

How do you troubleshoot a gas golf cart?

Instructions Check the gas tank to make sure there is enough fuel for operation. Remove the oil dipstick and check that the oil level is at or just above the add or fill maker. Inspect the battery of the golf cart. Examine the wiring and switches. Remove the air filter from the engine to access the carburetor.

How do I know if my golf cart solenoid is bad?

If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.

Why is my Yamaha golf cart smoking?

A smoking golf cart is not typically a problem with electrical models because there are very rare issues that may cause them to smoke. Typically, extra smoke coming from your engine usually indicates that the oil is being burned too heavily or even that the oil is running out in your engine.

How do you test a fuel pump on a club car?

A simple way to determine the fuel flow is to remove the fuel hose at the carburetor and hold over a small container. Attempt to start the engine and if all is well, the fuel should spurt out with reasonable force in pulses as the crankcase pressure varies. We hope you’ve enjoyed out tutorial on golf cart fuel pumps.

Why does my golf cart only run with the choke on?

4 Answers. Dwight Coleman there are usually only a few possibilities if it only runs with the choke. One cause could be an air leak on the carb, head gasket, crankshaft seal. The other could be a clogged low speed and idle circuit.

How do you adjust the governor on a EZ GO TXT gas golf cart?

How to Adjust the Governor on a Gas E-Z-Go Golf Cart Locate the governor arm mounted on top of the rear axle case underneath the cart. Loosen the adjusting locknut on the end of the governor spring. Retighten the adjusting locknut.

Why does my ezgo gas golf cart lose power?

Another fairly easy fix for your golf cart losing power, spotting frayed or loose wires is a critical way of ensuring that your cart is operating smoothly and efficiently. Look for any problems with the wire connection spots. Replace wires and wire connectors to minimize these issues.

What makes a gas golf cart start?

In a gasoline-powered golf cart, the engine starts when you step on the gas pedal, and it shuts off when you take your foot off the gas. That feature helps save gas, cuts down on emissions and helps keep the course quiet, too. Electric golf carts use batteries to power an electric motor.

Why does my gas golf cart not start?

Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up. Other battery issues, such as off-kilter wiring or corrosion and melted wires could be causing your ignition. If you find a leak, you’ll need to replace the battery itself.

What causes a golf cart not to start?

If you try to start your cart and don’t hear that “click,” it’s likely an issue with your solenoid. If you’re lucky, the problem could be as simple as a loose wire or a broken coil. In some cases, corrosion can also be a factor. If you suspect a faulty solenoid, your best bet is to take your cart to a repair shop.

What are symptoms of bad solenoid?

4 Signs of a Bad Starter Solenoid Engine Doesn’t Crank or Start. No Clicking Noise When Trying to Start the Engine. Starter Spins Without Fully Engaging the Flywheel (Rare) Engine Cranks Slowly (Rare) Test the battery. Check That Power is Getting to the Starter Solenoid. Test the Starter Solenoid Itself.